US bag and film recycling surpasses 1 billion pounds

By Gayle S. Putrich
Staff Reporter

Published: February 25, 2013 7:11 pm ET
Updated: February 25, 2013 8:21 pm ET

Related to this story

Topics Sustainability, Grocery bags, Packaging, Pallets/skids/materials handling, Shrink film, Recycling, Materials Suppliers
Companies & Associations American Chemistry Council

WASHINGTON — In 2011, more than 1 billion pounds of post-consumer plastic bags and films were collected for recycling in the United States, according to a new report.

That's a 4 percent increase from 2010 and a 55 percent increase from the 652.4 million pounds collected in 2005, according to the National Postconsumer Plastic Bag & Film Recycling Report, released Feb. 25 by the American Chemistry Council.

The report attributed the increase to growth in plastic and composite decking. Deck manufacturers accounted for 55 percent of the post-consumer film that was recycled, and they purchased 120 million more pounds of material in 2011 than they did in 2010.

The second largest market, film and sheet manufacturers, held steady at 100 million pounds in 2011, accounting for 16 percent of the total.

For the second year in a row, the majority of the post-consumer film collected in the United States was processed in the U.S. and Canada — 58 percent or 583 million pounds — with the remainder exported overseas.

Domestic volume was up 5 percent from 2010.

Mark Murray, executive director of Californians Against Waste, said there are some positive notes for environmentalists in the data, but they have to look past the modest increases in recycling rates.

"There's two bits of good news in the sense that the processing rate… has gone up a modest amount, 24 million pounds. And there's a shift… in terms of a greater percentage of the amount collected is going to North American processors rather than being shipped overseas. But there is still a lot of plastic film, plastic shrink-wrap, that is very recyclable that gets collected at the back of stores that is not being recycled," Murray said.

Moore Recycling Associates Inc. of Sonoma, Calif., has collected data for the annual bag and film recycling report for seven years.

The largest category of recycled film is what Moore Recycling calls "commercial clear" — clear, clean polyethylene film including stretch wrap and poly bags. The material accounts for 47 percent of the film that is recycled, a figure that is falling. Exactly how much it has dropped is difficult to pinpoint, though, in part because since this year's survey includes a new category, mixed color commercial film.

The report also notes that changes in the shipping market may have attributed to the decline for commercial clear film, including warehouse consolidation and adjustments in how retailers prepare pallets for shipment.

Murray said there needs to be more focus to recover commercial clear and other post-industrial, pre-consumer films.

"We need to get that behind-the-store shrink-wrap back into the recycling infrastructure," he said. "And really, this 'post-industrial, pre-consumer' plastic represents a success story that 10 years ago those were all corrugated boxes, which are much worse than shrink wrap for the environment," Murray said.

"It seems to me that we're moving in the right direction," he said.

The report estimated that 151 million pounds of post-consumer bags and sacks were recovered in 2011, a 19 percent increase from 2010. But the report cautioned that the lack of consistent data created uncertainty in this category.

The report also noted increases in other film categories, including curbside film collection. But it noted that the amount of curbside film being used domestically actually decreased in 2011. Curbside film is challenging to reprocess and the cost often exceeds the value of the end product, according to the report.

Information for the report was based on recovery data from 19 U.S. and three Canadian end users of post-consumer film and 37 companies that export consumer film.

ACC noted that there are currently more than 15,000 U.S. locations where consumers can bring their used polyethylene bags and wraps to be recycled, primarily at large grocery and retail chains.

"In-store collection is absolutely critical for recycling plastic bags, wraps and other flexible film packaging," said Steve Russell, ACC's vice president of plastics, in a news release.

"The infrastructure is there. The plastic film industry is now working to help grocers and retailers maximize the collection of this valuable material by sharing tools and best practices and through consistent customer education," he said.


Comments

US bag and film recycling surpasses 1 billion pounds

By Gayle S. Putrich
Staff Reporter

Published: February 25, 2013 7:11 pm ET
Updated: February 25, 2013 8:21 pm ET

Post Your Comments


Back to story


More stories

Image

Sealed Air's move to Charlotte will put it all under 'One Roof'

July 25, 2014 2:03 pm ET

Sealed Air Corp. shook the ground last week by announcing plans to relocate its headquarters from Elmwood Park, N.J., to Charlotte, N.C., in a move...    More

Image

Austrian mold maker seeking North American manufacturing partner

July 25, 2014 1:49 pm ET

An Austrian mold maker is looking for a manufacturing location in North America.    More

Image

DuPont resins help take Nike golf balls 'Fore!'ward

July 25, 2014 1:07 pm ET

It may be difficult to imagine just how much science, not to mention rubber and plastic components, go into a golf ball. But global giant DuPont Co....    More

Image

Bioplastics maker wins government funding

July 25, 2014 12:13 pm ET

Canadian bioplastics maker Solegear Bioplastics Inc. has won $1.6 million in funding from the government-sponsored Western Innovation Initiative...    More

Image

Report: biodegradeable plastics use in Europe to grow 12 percent

July 25, 2014 10:25 am ET

The biodegradable plastics market in Europe is forecast to witness 12 percent compound growth during 2014-19, according to TechSci Research's “E...    More

Market Reports

Plastics Recyclers Data Report & Directory

This exclusive MS Excel database contains all the companies from Plastics News' ranking of top North American Recyclers and Brokers by reprocessed volume and also includes a directory with materials processes, services offered and company contact information. Data is based on primary research by PN editorial staff.

Learn more

2014 Injection Molding Industry Report

GROWTH, OPPORTUNITY IN SIGHT FOR INJECTION MOLDERS IN 2014

In the wake of the economic turbulence earlier in this decade, molders today find themselves in much better shape. Molders are gaining a competitive advantage by investing in people, equipment and seeking inroads into new markets on a global scale.

Growth in the injection molding industry is going to be driven by low financing costs and a continued move to reshore some business.

Learn more

Shale Gas Market - Analysis of North American Region

This report highlights the impact of shale-based natural gas on the North American plastics market and features an in-depth analysis of production trends in the United States during 2013 and a forecast for 2014 and beyond.

Learn more

Upcoming Plastics News Events

September 10, 2014 - September 12, 2014Plastics Caps & Closures 2014

January 14, 2015 - January 14, 2015Plastics in Automotive

February 4, 2015 - February 6, 2015Plastics News Executive Forum 2015

More Events